The pilot of a Lion Air flight from Indonesia's Bali island made an alert call minutes after takeoff due to technical problems, but they were overcome and he pushed on to Jakarta.
The same jet crashed on another flight hours later, killing all 189 people on board.
Herson, chief of the airport authority for the Bali-Nusa Tenggara area, told Reuters that after the call on Sunday the pilot updated the control tower to say that the plane was flying normally and he would not return to the airport as requested.
"The captain himself was confident enough to fly to Jakarta from Denpasar," said Herson, who goes by one name, speaking by phone from Bali.
The pilot of another plane that was approaching Bali just after the Lion Air jet took off said he was ordered to circle above the airport and listened in to a radio conversation between the Lion Air pilot and air traffic controllers.
"Because of the Pan-Pan call, we were told to hold off, circling the airport in the air," said the pilot, who declined to be named.
"The Lion plane requested to return back to Bali five minutes after take-off, but then the pilot said the problem had been resolved and he was going to go ahead to Jakarta."
Pilots use Pan-Pan calls to flag urgent situations. They are a step down from Mayday, which signals severe distress.
The Denpasar-Jakarta flight landed at the Indonesian capital's airport at 10.55pm local time on Sunday.
The same Boeing 737 MAX jet took off at 6.20am the next morning, bound for Bangka island, off Sumatra, and plunged into the sea 13 minutes later.
Just before the crash, the pilot had made a request to return to base.
A Lion Air spokesman declined to comment when asked about the distress call on the earlier flight, citing the ongoing crash investigation.
The budget airline's chief executive Edward Sirait said earlier this week that a technical problem had occurred on the Denpasar-Jakarta flight but it had been resolved "according to procedure".
Amid media speculation over the airworthiness of the aircraft, the transport minister suspended Lion Air's technical director and three other officers on Wednesday to facilitate the crash investigation.
During its earlier flight from Bali on Sunday the aircraft flew erratically and its airspeed readings were unreliable, according to an accident investigator and a flight tracking website.
According to data from FlightRadar24, the jet displayed unusual variations in altitude and airspeed in the first several minutes of flight - including an 267-metre drop over 27 seconds when it would normally be ascending - before stabilising and flying on to Jakarta.
Divers on Thursday retrieved a flight data recorder from the plane that lay shattered on the muddy sea floor off the coast of Jakarta.
The NTSC said it would examine the device to get a clearer picture of what happened on the flight from Bali on Sunday in addition to the flight that crashed on Monday.
